X hits on this document

94 views

0 shares

0 downloads

0 comments

30 / 50

Table of Contents

Section 6: Maintenance

Engine Air Filter

Refer to Figure 6-7

Air Cleaner Cover

Air Cover Knob

A specially designed high density paper filter element surrounded by an oil filled foam precleaner filter element cleans the air supplied to the engine. Protect your engine by ordering only genuine Land Pride parts when replacing the air filter elements.

NOTE: Do not operate engine with a damaged air filter or without the air filter elements installed. Dirt will enter the engine and cause a dust ingested engine failure.

21368

Figure 6-7

Air Filter Maintenance Schedule

  • Check air filter daily before starting engine for dirt and debri buildup. Also check daily for loose and damaged filter components. Tighten loose components and replace damaged components.

  • Service precleaner foam element ever 25 hours of operation. Service more often when operating in extremely dusty or dirty conditions.

  • Service paper element every 100 hours of operation. Service more often when operating in extremely dusty or dirty conditions.

Element

Element Cover

Cover

Wing Nut

Precleaner Foam Element Refer to Figure 6-7 and Figure 6-8

  • 1.

    Prepare vehicle for maintenance as outlined in steps 1-6 on page 22.

  • 2.

    Safely secure the seat console in the raised position.

  • 3.

    Loosen air cleaner cover knob and remove cover.

  • 4.

    Remove outside precleaner element from the paper element.

  • 5.

    Wash precleaner element with warm water and detergent. Rinse thoroughly to remove all traces of detergent. Do not wring precleaner. Squeeze excess water out and allow time to air dry.

  • 6.

    Saturate precleaner with new engine oil and gently squeeze all excess oil out.

  • 7.

    Inspect precleaner element for holes and tears before reinstalling it. Replace element if damaged.

  • 8.

    Reinstall precleaner element over the paper element being careful not to damage the elements.

  • 9.

    Reinstall air cleaner cover and secure with cover retaining knob.

Order genuine Land Pride parts when replacing the

precleaner element. Description

Part No.

Precleaner Element (61 mm deep) . . . . 24-083-02-S

Paper Element Refer to Figure 6-7, Figure 6-8 and Figure 6-9

1.

Prepare vehicle for maintenance as outlined in steps 1-6 on page 22.

2.

Safely secure the seat console in the raised position.

Paper Element Behind Precleaner

Precleaner Foam Element

21369

Figure 6-8

Air Cleaner

Rubber Seal On

Base

Air Cleaner Stud

21370

Figure 6-9

  • 3.

    Loosen air cleaner cover knob and remove cover.

  • 4.

    Remove element cover nut, element cover and paper element with precleaner element.

  • 5.

    Remove precleaner element from paper element. Service precleaner as described in Precleaner Service Procedure.

  • 6.

    Do not wash paper element or blow pressurized air over and through it. This will damage the element. Always handle the element, new or used,

28

4400EX Heavy Duty Off Road Utility Vehicle 720-051M

7/14/08

Document info
Document views94
Page views94
Page last viewedMon Dec 05 01:05:03 UTC 2016
Pages50
Paragraphs2438
Words24423

Comments