X hits on this document

125 views

0 shares

0 downloads

0 comments

32 / 50

Table of Contents

Section 6: Maintenance

Maintenance Schedule

Maintenance Operation

Daily

Every 25 Hrs

Every 100 Hrs .

Every 200 Hrs.

Every 6 Mos.

Every Season

Refer to Page

Check Engine Oil level Check Hydraulic Fluid Level (1) Check Tire Pressure Check for Fluid Leaks Inspect All Nuts and Bolts for Tightness Check and Clean Area Around Air Intake

Grease Zerk Fittings for rotating surfaces - 2 places

X X X X X X X

31 35 23

22 28 36

Service Air Cleaner Pre-cleaner Foam Element(2)

X

28

Check Wheel Lug Nuts (Torque 65 to 75 Ft. lbs.) (3)

X

22

Grease Zerk Fittings for bearings - 3 places Service Air cleaner Paper Element (4) Change Engine Oil (5) & (6) Change Engine Oil Filter (5) & (6) Check Differential Fluid Level (7) Check Transmission Fluid Level (8) Check Battery Charge and Water Level Inspect Drum Brakes Inspect Parking Brake Check Master Cylinder Brake Fluid Check & Regap Spark Plugs (1.02 mm / .04 in.) Check Fuel Line Hoses and Clamps Replace In-line Fuel Filter Clean Battery and Terminals Check Power Steering Belt Clean Spark Arrester (9) Service Bendix starter drive (10) Disassemble and clean solenoid shift starter (10)

X X X X X X X X X X

X

X X X X

X X X X X X X

35 & 36 28 32 32 33 34 23

34

26 26 23 27 29

  • (1)

    Reservoir should be 3/4 full when all hydraulic accessories are in retract position.

  • (2)

    Replace air cleaner pre-cleaner if damaged.

  • (3)

    Check tightness after first 2 hours of initial operation and 2 hours after removal for repair and/or replacement.

  • (4)

    Replace paper element if extremely dirty or damaged.

  • (5)

    Make first oil and filter change after the first month of operation or at 20 hours of operation (whichever comes first).

  • (6)

    Service every 100 hours or 6 months (whichever comes first).

  • (7)

    Change differential oil ever year or every 400 hours (whichever comes first).

  • (8)

    Transmission fluid does not require changing unless contaminated with water. Change immediately if contaminated with water.

  • (9)

    Clean spark arrester whenever loss of engine power is noticed or every season (whichever comes first).

  • (10)

    Have a Land Pride dealer perform this service every year or every 500 hours (whichever comes first)

30

4400EX Heavy Duty Off Road Utility Vehicle 720-051M

7/14/08

Document info
Document views125
Page views125
Page last viewedSun Dec 11 06:58:13 UTC 2016
Pages50
Paragraphs2438
Words24423

Comments