X hits on this document

85 views

0 shares

0 downloads

0 comments

46 / 50

Probable Causes Neutral switch is not engaged.

Suggested Remedies

Adjust neutral switch to be engaged with gear shift in neutral.

Neutral switch is defective. Battery power is low.

Replace neutral switch. Recharge battery. Clean and tighten battery connections.

Battery connections are loose or corroded.

Battery is worn out or defective. Harness connections are loose. Harness pin connections are bent. Harness is defective. Ignition switch is defective. Starter is defective. Improper tire inflation.

Replace battery. Reconnect harness connections. Straighten harness pins. Replace harness. Replace ignition switch. Replace starter switch. Inflate all tires to correct tire pressure.

Hydraulic steering cylinder is not operating properly.

Inspect thoroughly and replace or tighten malfunctioning components.

Worn mounting bushings at hydraulic cylinder connecting pins.

Inspect and replace all worn bushing and connecting pins.

Malfunctioning steering sector.

Inspect and repair worn parts.

Throttle cable housing is set too close to engine preventing proper cable movement.

Reposition cable housing toward seats until all cable slack is removed between cable housing and engine.

Carburetor is icing up. Clutch out of adjustment. Clutch worn out.

Install Cold Weather Kit. Adjust clutch linkage. Replace clutch.

Section 11: Troubleshooting

Symptoms Starter does not work

Steering does not track correctly

Steering play is excessive

Vehicle speed does not reach 17 MPH

Vehicle looses ground speed without loosing engine speed

Table of Contents

44

4400EX Heavy Duty Off Road Utility Vehicle 720-051M

7/14/08

Document info
Document views85
Page views85
Page last viewedSat Dec 03 12:51:48 UTC 2016
Pages50
Paragraphs2438
Words24423

Comments